JD VIP Buyers Club
JD on Facebook
JamestownTV
JD Points Program
Request A Free Catalog

MSDS- TotalBoat Gleam Marine Spar Varnish


MATERIAL SAFETY DATA SHEET ------ To comply with OSHA Hazard Communication Standard 29 CFR 1910.1200 Essentially Similar to OSHA-174 ------ PRODUCT IDENTIFICATION: 8089-2/409314 TOTALBOAT GLEAM, MARINE SPAR VARNISH DATE PREPARED: 07-JAN-2014 PREPARED BY: COMPLIANCE OFFICER HMIS HAZARD DESIGNATION Health: 1 Slight Flammability: 2 Moderate Reactivity: 0 Minimal Personal Protection: G Glasses, Gloves, Respirator ------ SECTION I - MANUFACTURER INFORMATION MANUFACTURER'S NAME: CAMGER COATINGS SYSTEMS, INC. STREET ADDRESS: 364 MAIN STREET CITY, STATE, ZIP: NORFOLK, MA 02056-1249 TELEPHONE NUMBER FOR INFORMATION: (508) 528-5787 ------ SECTION II - HAZARDOUS INGREDIENTS * Indicates Item subject to reporting requirements of SARA 313,40 CFR 372. # Indicates OSHA "SKIN DESIGNATION" exposure hazard (29 CFR Table Z-1-A). Materials listed for this product are on the TSCA inventory list. ------ INGREDIENT C.A.S. NUMBER OSHA-PEL ACGIH-TLV WT% METHYL ETHYL KETOXIME 96-29-7 1 - 3 Stoddard Solvent/Mineral Spirits 8052-41-3 500 ppm 100 ppm 18 - 21 Aliphatic Petroleum Distillate 64742-88-7 350 MG/M3 23 - 28 ------ SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS BOILING RANGE (DEG F.): 310 to 405 SPECIFIC GRAVITY: 0.886 WPG: 7.38 VAPOR PRESSURE (mm/hg): 3 V.O.C. (Minus Exempt): 408 Grams per liter VAPOR DENSITY: Heavier than air EVAPORATION RATE: slower (Than n-butyl acetate) SOLUBILITY IN WATER: 0.0 % Soluble APPEARANCE AND ODOR: A CLEAR GLOSS colored material with a ALIPHATIC type odor ------ SECTION IV - FIRE AND EXPLOSION HAZARD DATA FLASH POINT (deg. F.): 104 Tag Closed Cup LEL: .70 % UEL: 6.00 % EXTINGUISHING MEDIA: Foam,Dry chemical or carbon dioxide. SPECIAL FIRE FIGHTING PROCEDURES: Use of a self-contained breathing apparatus is recommended for firefighters. Water may be unsuitable as an extinguishing medium, but is helpful in keeping adjacent containers cool. UNUSUAL FIRE & EXPLOSION HAZARDS: Keep away from heat, sparks, open flames. Vapors can cause a flash fire. Vapors might also ignite explosively. ------ SECTION V - REACTIVITY DATA STABILITY: STABLE (XX) UNSTABLE ( ) HAZARDOUS POLYMERIZATION: MAY OCCUR ( ) WILL NOT OCCUR (XX) BY PRODUCTS OF DECOMPOSITION: Carbon dioxide,Carbon monoxide COMPATABILITY (Materials to Avoid): Acids,Alkaline materials,Strong oxidizing agents ------ SECTION VI - HEALTH HAZARD DATA ROUTES OF ENTRY: INHALATION: Yes SKIN: No INGESTION: Yes CARCINOGENICITY: NTP? No IARC MONOGRAPHS? No OSHA REGULATED? No HEALTH HAZARDS: ACUTE - Inhalation - temporary dizziness, headache, possibly nausea. Symptoms will disappear when exposure ceases. Eye or skin contact - May cause discomfort by defatting action of solvents. CHRONIC - Repeated contact with skin may cause dermatitis. SIGNS & SYMPTOMS OF EXPOSURE: Temporary dizziness, headache, possibly nausea, dermatitis. TARGET ORGANS (Organs Effected): Eyes,Respiratory,Skin EMERGENCY FIRST AID PROCEDURES: Remove patient to fresh air. Eye Contact - Flush eyes with water for 15 minutes. Contact physician. Ingestion - DO NOT induce vomiting. Call physician at once. Skin contact - Wash skin with soap and water. ------ SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE STEP TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Remove sources of ignition and provide ventilation. Provide respiratory protection. Large spills may be scooped up with non-sparking tools. Small spills may be picked up with absorbent material. Place in closed container outdoors for disposal. WASTE DISPOSAL METHOD: In accordance with local,state and federal regulations. PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool place away from sources of heat,sparks or open flame. DO NOT BREATHE SPRAY MIST. SPRAY MIST IS FLAMMABLE. OTHER PRECAUTIONS: Ground container when pouring. Avoid the use of plastic container to prevent static electricity buildup. Also limit free fall to a few inches to prevent static sparks. DO NOT cut,puncture, or weld on or near empty container. ------ SECTION VIII - CONTROL MEASURES RESPIRATORY PROTECTION: Use a NIOSH approved chemical cartridge type respirator in accordance with OSHA respirator protection requirements under 29 CFR 1910.134 if LEL or TLV is above recommended level. VENTILATION: Use a local exhaust fan if the vapor concentration is above the LEL (lower explosive limit) and TLV (threshold limit value). GLOVES: Neoprene rubber gloves. EYE PROTECTION: Goggles or side shield spectacles. OTHER PROTECTIVE EQUIPMENT: A safety shower and eye bath should be made readily available.

JD on Facebook Live Tech Support JD Customer Photo Gallery Free Catalog